Bookbinding at Home Part 4: Materials and Meanderings

Suggested Blog Posts

• 
  January 10, 2023

  We’ve watched all of the YouTube reviews of our Sendak Artist Roll (thank you!) and have made our own video to answer some questions and share our experience!

  We are grateful for all the wonderful Sendak reviews, and for sharing videos and spreading the word!

  

  We’ve watched all of the YouTube reviews of our Sendak Artist Roll (thank you!) and have made our own video to answer some questions and share our experience!

  We are grateful for all the wonderful Sendak reviews, and for sharing videos and spreading the word!

  Video Transcript

  Hello, everyone! I wanted to give you a little walkthrough of our Sendak Artist Roll. I've been seeing a lot of other people's video walkthroughs and it's been inspiring me to do the same.

  Introduction

  Here is my very well-loved and very well-used Sendak. This is the first "right one" that we made. We went through a lot of trial and error to get to this, so I want to show you what it has the potential to hold.

  

  
  Supplies in my Sendak: Scissors and Glue (0:30)

  I always have glue with me because I do a lot of messy collage work, so I love to glue things and I also have scissors for that same reason. I use small scissors if I'm traveling anywhere where I'm getting on a plane, and I use big scissors if I'm just traveling in a car. Both sizes fit into the Sendak nicely. I tend to put the big scissors on an end, in one of the smaller pockets. The smaller scissors fit anywhere, it just depends what else I have in my Sendak.

  The Pencil Pockets (0:55)

  One of the most common requests that we get and one of the things that people tend to comment on is that these pencil pockets are too small for fountain pens. While that's true of this Kaweco cap (the bottom fits, the top doesn't), this vintage technical pen is pretty chunky, and I put it in there all the time. I carry two or three. You can see how it kind of draws the Sendak together, so ultimately there's going to be a little bit less room in other pockets. It's making other things more tight, but really, it's fine.

  When the Sendak is new, the waxed canvas might be tight to even just fit a pencil, but as you use it, it breaks in and loosens up, and then it doesn't loosen any further – that's where it's going to stay. Once you use it more, you can easily fit two standard pencils or paintbrushes into each slot, so it's really not a too small slot once you break it in. 

  

  
  Supplies in my Sendak: Pencils (1:35)

  I love these beginners pencils that have really soft lead. I love making marks that are a little less particular than, for example, when I'm using my mechanical pencils (which I also love).

  So, these are some of the supplies that I carry every day. I think where the variation comes in, is in which pencils I want, which softness levels, or if I want a water soluble pencil. I'll put the pencils together in this end pocket. It's important to note that the Blackwing fits in. This Blackwing pencil was sharpened once and it makes it a perfect fit. This one was never sharpened, and the eraser is worn down a bit, so it's just above that folding point (the Sendak measures 7.75″ tall at the folding point). The taller one will obviously still work, but I know these are awesome pencils that a lot of people have, so I wanted to show you that.

  Supplies in my Sendak: Pens (2:15)

  Another thing that I carry are dippy pens. I will put pen nibs into a tin. I love using antique tins to store pen nibs, and in this case, a kneaded eraser. These tins are great for little art supplies, and I just put them into the zipper pocket.

  The Zipper Pocket (2:30)

  In addition to the vintage tin, I put another regular eraser. When pencils get too small for the pencil pockets, then I'll put them in the zipper pocket. I also have some extra lead for my mechanical pencils, a pencil sharpener, and I often have a whitewash in there as well. You can fit a lot in this zipper pocket.

  I like to not overstuff my Sendak so that it folds nicely. I really like it to fold up rather than to roll up, which happens when it is very stuffed.

  The Interior Pockets (2:55)

  We have 16 pen and pencil slots in the front, and then we have four pockets behind those. So these four are varying widths – you could see the width of the smaller ones that I use for scissors or pencils, which measure 2.5″ wide. The larger two measure 4.25″ wide. I use these two bigger pockets for sketchbooks.

  We make these Landscape Orra Sketchbooks in our shop. We designed them to fit into both this Sendak and the Mini Sendak. They can also serve as a tool protector if you need it, for example, if I was putting in a dippy pen whose nib needed protecting, or paint brushes, that would be a great tool protector. We also sell acrylic tool protectors separately if you don't want to carry a Sketchbook or Painter's Palette.

  The Iris Painter's Palette is another product that we make. It is for squeezing in tube paints, watercolors, or in this case, making your own paint and filling up these wells with homemade paint. This was made to fit in both the Classic Sendak and the Mini Sendak as well, in these large interior pockets.

  

  I'm going to put my palette here, and these pens in the back here with some small scissors. I want to have another paint brush and then whatever colors I want to bring. Sometimes I get really organized and other times I just put stuff in. You don't have to be crazy overthinking this. It's just really supposed to hold what you need – what you need for the day, what you need for a week, what you need for a trip.

  I also often have a bookbinding needle held in the top flap here, and I'll put some bookbinding thread here in the zipper pocket, in case I want to make a book. I'll also prepare by having folded paper here in these exterior pockets.

  The Exterior Pockets (4:30)

  These two outside pockets otherwise are great for random sized sketchbooks like this – this would have been one of those random ones that I made. I also love this tin. It's for 15 neocolors, but I've had it for years and I move pastels or other more delicate stuff into here that I don't want to crumble in the pen pockets. It's a really nice fit for these back pockets.

  

  This is our Orra Portrait Sketchbook, which we made to fit into the Classic Sendak. We have three sizes of these sketchbooks – the Portrait, the Large Portrait, and the Landscape.

  Closing the Sendak (5:00)

  So when I fold up the Sendak – this one is pretty full with everything that I just stuffed into the outside pockets – but when I fold it up, I will hold everything down and pull down this top flap so that it folds nicely. Then I roll in the sides, starting with the zipper pocket, so that all the parts of my Sendak are where they should be. Then I just synch it closed with the leather strap and buckle.

  I'd say this is pretty full – I have stuff in every pocket. In some instances, I have more than one thing in a pocket. There's still a lot of room on this leather strap. So that's it! This will fit nicely into my bag, and I've got what I need for a long time.

  

  The Buckle Closure

  Another question that we've had is about this buckle. This comes from a gun sling from maybe the forties, and it was intended to function exactly as we use it. We found that it just really holds the Sendak together nicely, and of course, we love incorporating old bits wherever we can, into whatever we make.

  So there you have it! My Sendak, lovingly worn in and full of life.

  

  Mentioned in this video:

  
  From Our Shop:

  • The Classic Sendak Artist Roll
  • The Sendak Mini Artist Roll
  • Iris Painter’s Palette
  • Landscape Orra Sketchbook
  • Portrait Orra Sketchbook
  • Acrylic Tool Protects (Out of Stock)

  From Other Shops:

  • Blackwing Pencils
  • Kaweco Pens
  • Neocolor
  • Vintage art supplies (dippy Pens, technical pens, tins) are from flea markets and sometimes eBay!

  Related Blog Posts:

  • Press: Sarah Dyer Reviews the Peg and Awl Sendak on Jackson’s Art Supplies Blog

  The Sendak Artist Roll: A Walkthrough Video

  We’ve watched all of the YouTube reviews of our Sendak Artist Roll (thank you...

  Read The Post
• 
  August 13, 2022

  The world is bursting with magic, and for anyone looking, it positively pulses. As a family of life-long learners, we felt compelled to share a few of our favorite activities in one compact notebook of removable cards.

  

  The world is bursting with magic, and for anyone looking, it positively pulses. As a family of life-long learners, we felt compelled to share a few of our favorite activities in one compact notebook of removable cards.
  
  

  The Specimen Card Notebook
  
  

  Whether embarking on a backyard exploration, a community science project, traveling near or far, or identifying mysterious objects around your house, these cards encourage observation, drawing, writing, and a touch of research.
  
  Tear them out, and hang them up, give them as gifts, or keep them intact as a journal. However you use them, we hope they inspire you to always keep an eye out for the little things!

  Specimen Card Notebook

  The world is bursting with magic, and for anyone looking, it positively puls...

  Read The Post
• 
  July 23, 2022

  

  The Scout Plein Air Box was inspired by our endeavor to make art every day. Each one is handmade in our Philadelphia workshop. Watch our video showing how we make the Scout Plein Air Box!

  The Scout Plein Air Box was inspired by our endeavor to make art every day. Each one is handmade in our Philadelphia workshop. It compactly secures all of your essential art supplies for painting outdoors. Fill your box with your favorite colors, paintbrushes, and sketchbook. Find your spot and quickly transform the box into a mini studio. Set it on a flat surface or mount it on a tripod, snap the liquid jars, brush holder, and easel in place, clip on your canvas and you are ready to paint. Watch our video showing how we make the Scout Plein Air Box!
  
  

  Original Plein Air Oil Paintings by Walter Kent

  “It has been nearly three years since I returned from a painting workshop in Italy, taught by Jeremy Mann and Nadezda, hosted by Art Escape Italy. This was my first experience plein air painting and once I returned home I immediately made my own pochade box, the Scout. During the last three years I have gone out on many painting adventures, both alone and with my family, with the Scout over my shoulder.
  
  When I wander out into the world to paint, there is a game of tug of war twisting knots in my stomach, with my hopes and fears digging their heals in on either side. After the first few strokes of paint, the excitement of possibility takes over. These attempts at capturing the fleeting moments of the world around me line the windowsills of our studio.

  I’ve selected some of my favorite Plein Air oil paintings, breadcrumbs of my path as an artist, and we are excited to share them with the everyone. Each painting has been varnished for protection and is signed and marked with its location and date and is fitted with a ready-to-hang frame made of reclaimed blackened walnut.” –Walter

  Indian Lake, New York 2022	Shaw’s Bridge, Pennsylvania 2021

  

  Delaware Water Gap No. 3, Pennsylvania 2021

  Barnegat Bay, New Jersey 2020	Starr Farm, Pennsylvania 2021

   

  

  Kaaterskill Falls, New York 2022

  Lake Superior, Wisconsin 2020	Kerhonkson, New York 2022

  

  Ready-to-Hang frames are made of reclaimed blackened walnut.

  How We Make the Scout Plein Air Box and Original Paintings by Walter Kent

  The Scout Plein Air Box was inspired by our endeavor to make art every day....

  Read The Post
• 
  February 17, 2023

  We put together a little video so you can make your own book for the #100dayproject! Enjoy, ask questions, and share with us on Instagram so we can see your projects too!

  

  We put together a little video so you can make your own book for the #100dayproject! Enjoy, ask questions, and share with us on Instagram so we can see your projects too!

  #qbbc100days
  #quarantinebookbindingproject
  #pegandawlbinds

  Please note: this tutorial is specifically about page count. Click here for the full Bookbinding at Home Tutorial: Stitching a Coverless Journal. 

  In this video, I’m making two books at a time, both specifically made for the 100 day project. They are both the same size with just a few variations. I find this project to be a really nice reason to get out and observe the world.

  These are the two journals, highlighting different colors and vintage textiles!	Here you can see a full journal spread dedicated to one day!

  When you’re making a book for a particular project, it’s really important to consider both paper size and page count of your book. I’m making this book for my 100 day project, so I’m going to consider how many pages I will need for the 100 days. Usually, I like to dedicate a full spread to one day, so I’m going to need double the pages, though in some instances, I’ll use one page per day.

  Journal Page Planning

  
  
  

  
  If your 100 day project will consist of one spread per day, then you will need 52 sheets, which is the size of one full page spread open. Once you fold a single sheet in half, it’s called a folio. You'll be putting 4 folios inside of each other and that will make up one signature. You will have a total of 13 signatures. That will give you 202 pages, not counting the front and back cover. The few extra pages can come in handy for notes or whatever you may want to add.

  If you want to make a book that is dedicating one page to a day, then you will need 27 sheets. You’ll be putting 3 folios inside of each other, and that will make up one signature. You will have a total of 9 signatures. And this will give you 106 pages not counting the front and back cover.

  Bookbinding Glossary

  Sheet: The unfolded paper pages that you start your project with
  Folio: A folded sheet
  Signature: Gathering of folios
  Leaf: One half of a folded sheet
  Page: Each side of each leaf
  
  

  Now that I’ve finished folding and tearing my signatures, I’m going to measure out where I want the textiles to be sewn onto the spine of the book. I’m going to start with my quarter inch ends – this is for the end knots. 

  The end knots form lines along the ends.

  Measuring and marking my linen and thread layout on one signature.	Then, marking another signature and putting one in front and one in back of the stack.

  Usually, I would now put these signatures into a clamp, and use a ruler to connect the front and back markings in a straight line. However, if you don't have a clamp, these double-sided marks will help. In the video, you can see how I use a jeweler saw to make the holes, instead of poking them one at a time (once again, for full instructions: Bookbinding Tutorial - How to Sew a Coverless Journal).

  Now I am just going to cut some of this wonderful vintage textile that I found in an abandoned house. 

  I am making the strips an inch wide so they can really show off the pattern.	A lot of you have been asking what kind of thread I am using; this is a 3 ply waxed Irish Linen thread.

  I have 13 of these signatures, and I’m going to measure 13 lengths of wax thread, slightly larger than the length of the spine. I don’t want a lot of extra thread, because the longer your thread is, especially for a big book like this, the more tangled it’s going to get while you’re sewing. Also, if you cut your thread too short so that you have less to manage, you’re going to have to knot it somewhere in your book, which is not a big deal (but I don't like doing it).

  This feedsack textile was in a bundle that I found in my favorite abandoned house that belonged to Flossie and Jack.	Step-by-step sewing instructions!

  I have been incorporating antique materials of all kinds into the work that I do for most of my life. I love the stories that they hold, the character, and the quality of these old things. This fascination is what started me off on incorporating textiles into my journals. 

  My friend and I found all of Flossie’s dresses in the attic of her abandoned house; we washed them and wore them for years. We saw all the evidence of the patching and the stitching as these were likely from the depression era. 

  This red feedsack was originally stitched together to make a bag for grain, and then people would use the patterns and the normal cotton feedstock textiles to make clothes; so this was most likely the negative space from the pattern that was cut, and then they used a piece to tie the entire bundle together.

  I am using this delightful leftover for my journal. 

  Just one stack of many vintage textiles we’ve used in our projects.	Can you spot the vintage touches in these past sketchbooks?

  I’ve participated in this challenge for the last few years, as it encourages me to make marks daily. Some of the drawings in these sketchbooks took 5 minutes, others took hours. It doesn’t matter how long I spend with each drawing, just that I sat down to make some marks.

  In 2021 I used Noodlers Black Ink (with the catfish on the front) and my left (non-dominant) hand for my 100 Day Project. I loved it so much that I've done it for nearly 300 days out of the year - that is three #100dayproject notebooks and a rather newly-skilled left hand!

  A finished project.	At my desk, with my Sendak Mini and Beatrix Caddies.

  I've been sharing my drawings on my art/family account on Instagram @thebrotherskent.	I also write with my left hand. It was such a different experience from my meandering Morning Pages!

  Planning a Journal for the 100 Day Project

  We put together a little video so you can make your own book for the #100dayp...

  Read The Post
• 
  April 15, 2022

  Whether embarking on a backyard exploration, a community science project, travelling near or far, or identifying mysterious objects around your house, these cards encourage observation, drawing, writing, and a touch of research. However you use them, we hope they inspire you to always keep an eye out for the little things!

   

  

   

  The world is bursting with magic, and for anyone looking, it positively pulses. As a family of life-long learners, we felt compelled to share a few of our favourite activities in one compact notebook of removable cards (coming soon!). We are now in our 4th year of officially homeschooling our boys, which means full time of the stuff we did around the edges of their ‘normal’ education at public school.

  We love the unknown and the ‘around the edges’ stuff like family bike rides, traveling, and art all day, and have always found places like Kahn Academy and Skillshare, to be grounding companions. With so many students of the world currently homeschooling, or hodge-podge schooling via Zoom and Flipgrid (like we are!), we have decided (thanks Silas!) to unearth this Peg and Awl project have turned it into a free downloadable PDF: Specimen Cards! 

  Whether embarking on a backyard exploration, a community science project, travelling near or far, or identifying mysterious objects around your house, these cards encourage observation, drawing, writing, and a touch of research. However you use them, we hope they inspire you to always keep an eye out for the little things!

  Download the Printable PDF

  

  Silas drawing daffodils on a portable desk made by Søren!	Silas shows me his mushroom specimen!

  Sampling of the coming soon Specimen Card notebook.	Collection of Specimen Cards by Silas!

  Designing the Specimen Card book – including Silas's original drawings!	Closeup of updated Specimen Card, nearly finalized!

  Specimen Cards + Homeschooling (Free Printable)

  The world is bursting with magic, and for anyone looking, it positively puls...

  Read The Post